GENERAL PAINT & CHEMICAL COMPANY -- HI-Q GLOSS ENAMEL  -- 8010-00N009754
<pre>=====================  Product Identification  =====================

Product ID:HI-Q GLOSS ENAMEL
MSDS Date:03/13/1986
FSC:8010
NIIN:00N009754
=== Responsible Party ===
Company Name:GENERAL PAINT & CHEMICAL COMPANY
Address:201 JANDUS ROAD
City:CARY
State:IL
ZIP:60013
Info Phone Num:(312)639-5383
Emergency Phone Num:(312)639-5383
CAGE:GENEA
=== Contractor Identification ===
Company Name:GENERAL PAINT & CHEMICAL
Address:201 JANDUS ROAD
City:CARY
State:IL
ZIP:60013
Phone:(312) 639-5383
CAGE:GENEA

=============  Composition/Information on Ingredients  =============

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
Other REC Limits:150 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:XYLENES (O-,M-,P- ISOMERS)	(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:ACETONE  (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30%
Other REC Limits:1000 PPM
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:PROPANE/ISOBUTANE BLD
Fraction by Wt: 30%
Other REC Limits:1000 PPM
OSHA PEL:NOT KNOWN
ACGIH TLV:NOT KNOWN

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NOT KNOWN 
Routes of Entry: Inhalation:NO	Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
    SECTION .
Explanation of Carcinogenicity:NOT AVAILABLE 
Effects of Overexposure:SEVERE EYE IRRITATION; DRYING OF SKIN;
    EXCESSIVE INHALATION; CAUSES HEADACHE, DIZZINESS AND NAUSEA.
Medical Cond Aggravated by Exposure:NONE KNOWN TO GENERAL PAINT &
    CHEMICAL COMPANY.

=======================  First Aid Measures  =======================

First Aid:EYES:IMMED FLUSH EYES W/LGE AMTS OF WTR FOR AT LEAST 15 MIN.
    SKIN:WASH W/WARM WTR & SOAP. INGESTION:DO NOT INDUCE VOMITING. KEEP
    PERSON WARM & QUIET. GET MEDICAL ATTENTION. INHALATION:REMOVE TO
    FRESH  AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION .
    GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point:BLOW 50F/10C
Lower Limits:N/K 
Upper Limits:N/K 
Extinguishing Media:FOAM; "ALCOHOL FOAM"; CO*2; DRY CHEMICAL.
Fire Fighting Procedures:TREAT AS A VOL LIQ FIRE.WTR SPRAY MAY BE
    INEFF.IF WTR SPRY IS USED;FOG NOZZ ARE PREFER.WTR MAY BE USED TO
    COOL SEAL CNTNR TO PRVNT PRESS BLD-UP & POSS (SUP DAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXLODE WHN EXPOSED
    TO HEAT. ISOLATE FROM HEAT, SPARKS & OPEN FLAME.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL;
    ABSORB LIQUID W/CLAY, SAND/FLOOR ABSORBENT. PREVENT RUN-OFF TO
    SEWERS, STREAMS/OTHER BODIES OF WTR.
Neutralizing Agent:NOT KNOWN 

======================	Handling and Storage  ======================

Handling and Storage Precautions:HANDLE AS AN EXTREMELY FLAMM MATL.KEEP
    AWY FRM HEAT SPRKS & OPN FLM.FOR STOR COND SEE OSHA 1910.106.DO NOT
    EXPO/STOR AT TEMP OVER 120F/48.9C
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT
    W/SKIN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED
    RESPIRATOR IF TLV LIMITS ARE EXCEEDED. APPROVED MECHANICAL FILTER
    TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY
    APPLICATION.
Ventilation:PROVIDE SUFF MECH (GEN &/LOCAL EXHAUST) VENT TO MAINTAIN
    EXPOSURE BELOW TLV.
Protective Gloves:REQUIR TO PRVNT PRLNG/REPEA CNTCT.
Eye Protection:CHEMICAL WORKER GOGGLES.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS ARE SUGGESTED TO
    PRVNT PROLONGED/REPEATED SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING; SMOKING OR USING
    BATHROOM. DO NOT REUSE CONTAMINATED CLOTHING.
Supplemental Safety and Health
BP:57.2-137.8C.PH:N.FL PT MTD:N.SP FF PROC:EXPLO & AUTO-IGN WHN EXPO TO
    HEAT OF FIRE.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:135-280F OR
Melt/Freeze Pt:M.P/F.P Text:N/K 
Decomp Temp:Decomp Text:N/K 
Vapor Pres:N/K 
Vapor Density:HV THN AIR
Spec Gravity:N/K 
pH:N/K-FP
Evaporation Rate &amp; Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN 
Appearance and Odor:NOT KNOWN 
Percent Volatiles by Volume:83
Corrosion Rate:

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ISOLATE FROM HEAT & OPEN FIRE,
    TEMPERATURES ABOVE 120F/48.9C.
Hazardous Decomposition Products:CARBON DIOXIDE & CARBON MONOXIDE FROM
    BURNING.

====================  Disposal Considerations  ====================

Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
    LANDFILL IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
    DISPOSE OF CANS IN NON-INCINERATED TRASH ONLY.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.