RALPH WILSON PLASTICS CO -- CONTACT ADHESIVES, 950  -- 8040-00N024454
<pre>=====================  Product Identification  =====================

Product ID:CONTACT ADHESIVES, 950
MSDS Date:04/28/1988
FSC:8040
NIIN:00N024454
=== Responsible Party ===
Company Name:RALPH WILSON PLASTICS CO
Address:600 GENERAL BRUCE DR
City:TEMPLE
State:TX
ZIP:76501-5199
Country:US
Info Phone Num:817-778-2711
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:ELDEN C. CHEATHAM
CAGE:20706
=== Contractor Identification ===
Company Name:RALPH WILSON PLASTICS CO
Box:City:TEMPLE
State:TX
ZIP:76503-6110
Country:US
Phone:817-778-2711
CAGE:20706

=============  Composition/Information on Ingredients  =============

Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293

Ingred Name:1,3-BUTADIENE, 2-CHLORO-, POLYMERS; (NEOPRENE)
CAS:9010-98-4
RTECS #:EI9640000
Fraction by Wt: 10%

Ingred Name:PHENOLIC RESINS
Fraction by Wt: 5%

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <30%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: <30%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:HEXANE
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 50%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, MUCOUS MEMBRANES,
    SKIN. AT HIGHER CONCENTRATIONS, NARCOSIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:PROLONGED INHALATION MAY CAUSE HEADACHES,
    NAUSEA, SHORTNESS OF BREATH, DROWSINESS.
Medical Cond Aggravated by Exposure:UNKNOWN.

=======================  First Aid Measures  =======================

First Aid:INHAL: REMOVE VICTIM TO FRESH AIR. USE APPROPRIATE RESPIRATOR
    IF NECESSARY. INGEST: CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING.
    SKIN & EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
    SEEK M EDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TOC
Flash Point:15.0F,-9.4C
Lower Limits:2%
Upper Limits:13%
Extinguishing Media:CO*2, FOAM, SAND.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
    PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NEOPRENE GIVES OFF HCL WHEN BURNED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:APPLY SAWDUST OR SIMILAR MATERIAL TO SPILL
    AREA TO CONTAIN. SCOOP UP SPILL AND PUT IN SUITABLE CONTAINER. IF
    NECESSARY, USE SOLVENT TO REMOVE REMAINDER OF ADHESIVE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:AVOID CONTACT WITH EYES OR SKIN. AVOID
    BREATHING OF VAPORS.
Other Precautions:STORE AND USE ONLY IN WELL-VENTILATED AREAS; ALL
    ELECTRICAL EQUIPMENT IN AREA SHOULD BE EXPLOSION-PROOF.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR, FULL-FACE
    RESPIRATOR - ONLY IF NOT O*2 DEFICIENT.
Ventilation:MECHANICAL (GENERAL): PREFERRED.
Protective Gloves:NEOPRENE SUGGESTED.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE
Work Hygienic Practices:APPLY GOOD HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:132F,56C
Vapor Pres:185
Spec Gravity:0.822
Evaporation Rate &amp; Reference:7.7 (N-BUTYL ACETATE = 1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:VISCOUS LIQUID, STRONG KETONE ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:HCL WHEN BURNED.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS SOLID WASTE. DISPOSAL MUST BE IN
    ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.