IPS CORPORATION -- WELD-ON P-70 PRIMER FOR PVC PLASTIC PIPE -- 8010-00N003418 
=====================  Product Identification  =====================

Product ID:WELD-ON P-70 PRIMER FOR PVC PLASTIC PIPE
MSDS Date:11/01/1986
FSC:8010
NIIN:00N003418
=== Responsible Party ===
Company Name:IPS CORPORATION
Address:17109 S MAIN
Box:379
City:GARDENA
State:CA
ZIP:90248
Country:US
Info Phone Num:213-321-6515
Emergency Phone Num:800-424-9300 CHEMTREC/213-484-5151
CAGE:IPSCO
=== Contractor Identification ===
Company Name:IPS CORPORATION
Address:17109 S. MAIN ST.,
Box:379
City:GARDENA
State:CA
ZIP:90248
Country:US
Phone:310-898-3300
CAGE:17510
Company Name:IPS CORPORATION
Address:17109 SOUTH MAIN STREET
Box:379
City:GARDENA
State:CA
ZIP:90248
Country:US
Phone:310-366-3300
CAGE:IPSCO

=============  Composition/Information on Ingredients  =============

Ingred Name:TETRAHYDROFURAN (THF) (SARA III) ( PHYSICAL/CHEMICAL
    CHARACTERISTICS AND FLASHPOINT BASED ON THF)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: MAJOR
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:METHYL ETHYL KETONE (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: MINOR
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: V MINOR
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:DIMETHYLFORMAMIDE
CAS:68-12-2
RTECS #:LQ2100000
Fraction by Wt: V MINOR
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 10 PPM
ACGIH TLV:S, 10 PPM; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:SKIN-MAY IRRITATE SKIN. MAY PRODUCE
    CUMULATIVE INJURY WHEN REPEATEDLY ABSORBED THROUGH SKIN IN
    SUFFICIENT QUANTITIES. NORMAL DEFATTING EFFECTS OF SOLVENT ON
    TISSUE. INGESTION-MODERATE TOXIC HARMFUL IF  INHALED OR ABSORBED
    THRU SKIN. MAY CAUSE LIVER AND KIDNEY DAMAGE.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:INHALATION-SEVERE OVEREXPOSURE MAY RESULT IN
    NAUSEA, DIZZINESS, HEADACHE. CAN CAUSE NARCOSIS, IRRITATION OF EYES
    AND NASAL PASSAGE. EYES-LIQUID MAY CAUSE TEMPOARAY IRRITATION,
    PAINFUL BURNING OF EYES  AND LIDS, WATERING OF EYES AND
    INFLAMMATION OF CONJUNCTIVA. INGESTION-MAY CAUSE DIARRHEA & MENTAL
    SLUGGISHNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:INHALATION-REMOVE TO FRESH AIR AND IF BREATHING STOPPED, GIVE
    ARTIFICIAL RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS
    DIFFICULT, GIVE OXYGEN. CALL A PHYSICIAN. EYE & SKIN CONTACT-REMOVE
    CON TAMINATED CLOTHING & SHOES. WASH SKIN WITH PLENTY OF WATER FOR
    AT LEAST 15 MIN. FLUSH EYES WITH PLENTY OF WATER FOR 15 MIN & CALL
    A PHYSICIAN. INGESTION-IF SWALLOWED, DO NOT INDUCE VOMITING. CALL
    MD.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:6F,-14C
Lower Limits:2
Upper Limits:11.8
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM, ANSUL "PURPLE
    K", WATER FOG.
Fire Fighting Procedures:EVACUATE ENCLSD AREA,STAY UPWIND.CLOSE/
    CONFIND REQ SCBA,POS PRESSURE HOSE MASK/AIRLINE MASK.WATER SPRAY TO
    COOL CNTNRS,FLUSH SPILL FROM IGNIT,DISPERSE VAPOR.
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT
    AND HIGH VOLATILITY. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL TO
    SOURCE OF IGNITION.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIMINATE IGNITION SOURCES. AVOID BREATHING.
    KEEP LIQUID OUT OF EYES. FLUSH WITH LARGE AMOUNTS OF WATER. CONTAIN
    LIQUID WITH SAND/EARTH. ABSORB WITH SAND OR NONFLAMMABLE ABSORBENT
    MATERIAL & TRANSFER  INTO STEEL DRUMS FOR RECOVERY OR DISPOSAL.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN SHADE (40-110F). KEEP AWAY
    FROM HEAT, SPARK, FLAME, OTHER IGNITION SOURCES. AVOID PROLONGED
    BREATHING OF VAPORS.
Other Precautions:USE WITH ADEQUATE VENTILATION. FOLLOW ALL
    PRECAUTIONARY INFORMATION GIVE ON CONTAINER LABEL, PRODUCT
    BULLETINS & OUR SOLVENT CEMENTING LITERATURE. ALL HANDLING
    EQUIPMENT SHOULD BE ELECTRICALLY GROUNDE D.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NON REQUIRED WITH ADEQUATE VENTILATION. USE
    NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS FOR CONFINED AREAS,
    E.G., MINE SAFETY APPLIANCE CAT. #460968 WITH CHEMICAL CARTRIDGE
    #464031.
Ventilation:PROVIDE ADEQUATE VENTILATION. VAPOR CONCENTRATION MUST BE
    KEPT WELL BELOW TLV.
Protective Gloves:RUBBER OR PVA.
Eye Protection:CHEMICAL GOGGLES.
Other Protective Equipment:IMPERVIOUS APRON (IF NEEDED).
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE.

==================  Physical/Chemical Properties  ==================

HCC:F3
Boiling Pt:B.P. Text:151F,66C
Vapor Pres:143 MMHG
Vapor Density:2.49
Spec Gravity:.870+/-0.01
Evaporation Rate & Reference:INTIALLY-8 (BU AC=1)
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR OR PURPLE COLOR; ETHEREAL ODOR
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG
    OXIDIZERS AND ISOCYANATES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME
    AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:HYDROGEN DIOXIDE, HYDROGEN MONOXIDE,
    CARBON DIOXIDE, CARBON MONOXIDE & VARIOUS HYDROCARBONS.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT, SPARKS, OPEN
    FLAME AND OTHER SOURCES OF IGNITION.

====================  Disposal Considerations  ====================

Waste Disposal Methods:FOLLOW FEDERAL, STATE & LOCAL REGULATIONS.
    CONSULT DISPOSAL EXPERT. CAN BE DISPOSED OF BY INCINERATION.
    EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS. EMPTY
    CONTAINERS SHOULD BE AIR DRI ED BEFORE DISPOSING. HAZARD WASTE
    CODE:214.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.