ZEP MANUFACTURING COMPANY -- DRILL CHILL, 0045  -- 9150-00N019261
<pre>=====================  Product Identification  =====================

Product ID:DRILL CHILL, 0045
MSDS Date:07/27/1989
FSC:9150
NIIN:00N019261
=== Responsible Party ===
Company Name:ZEP MANUFACTURING COMPANY
Box:2015
City:ATLANTA
State:GA
ZIP:30301
Country:US
Info Phone Num:404-352-1680
Emergency Phone Num:404-435-2973 800-424-9300(CHEMTREC)
CAGE:72674
=== Contractor Identification ===
Company Name:ZEP MANUFACTURING COMPANY
Address:1310 SEABOARD INDUSTRIAL BLVD NW
Box:2015
City:ATLANTA
State:GA
ZIP:30318
Country:US
Phone:877-428-9937
CAGE:27674
Company Name:ZEP MANUFACTURING COMPANY
Box:2015
City:ATLANTA
State:GA
ZIP:30301
Phone:(404) 352-1680
CAGE:72674

=============  Composition/Information on Ingredients  =============

Ingred Name:PETROLEUM OIL, ALIPHATIC;(SULFATED PETROLEUM CUTTING OIL).
    LIMITS AS OIL MIST.
CAS:68815-10-1
Fraction by Wt: >80%
OSHA PEL:5 MG/M3
ACGIH TLV:5MG/M3;10 MG/M3 STEL

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:CAN BE AN EYE IRRITANT.
    INFLAMMATION OF EYE TISSUE IS CHARACTERIZED BY REDNESS, WATERING
    AND/OR ITCHING. OIL MISTS WHICH EXCEED THE ACGIH TLV/OSHA PEL OF 5
    MG/M3 MAY CAUSE RESPIRATORY IRRITATION . CHRONIC:THERE ARE NO KNOWN
    EFFECTS FROM CHRONIC EXPOSURE TO PRODUCT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:SKIN:WASH CONTAMINATED SKIN THOROUGHLY WITH SOAP OR MILD
    DETERGENT. APPLY SKIN CREAM W/LANOLIN. GET MD IF IRRITATION
    PERSISTS. EYE:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST
    15 MINUTES, OCCAS IONALLY LIFTING UPPER & LOWER LIDS. GETMD AT
    ONCE. INHAL: MOVE TO FRESH AIR. IF IRRITATION PERSISTS, GET MD
    IMMED. INGEST:DO NOT INDUCE VOMIT. IF VOMIT OCCURS, KEEP HEAD BELOW
    HIP LEVEL. GET MD IMMED

=====================  Fire Fighting Measures  =====================

Flash Point:FLAMMABLE
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:DIRECT STREAM OF WATER ONTO INTACT CONTAINERS.
    WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE IF EXPOSED TO HEAT
    ABOVE 120F.

==================  Accidental Release Measures  ==================

Spill Release Procedures:LARGE SPILLS UNLIKELY DUE TO AEROSOL
    PACKAGING. IF SPILLED, ABSORB W/INERT ABSORBENT MATL (E.G.
    ZEP-O-ZORB) PICK UP & DEPOSIT WASTE IN SEALABLE, DOT SPECIFICATION,
    CNTNR FOR DISP AS HAZ WASTE. THORO C LEAN SPILL AREA W/DETERGENT
    SOLUTION. RINSE THORO.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:CLOSE CONTAINER TIGHTLY WHEN NOT IN
    USE. STORE AWAY FROM SUN & HEAT. STORE AWAY FROM STRONG ACIDS &
    OXIDIZING COMPOUNDS. KEEP AWAY FROM SKIN & EYES.
Other Precautions:DO NOT BREATHE SPRAY MISTS OR VAPORS. KEEP OUT OF
    REACH OF CHILDREN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR PROPERLY
    FITTING NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:IF VAPORS ARE DETECTED, VENTILATE WORK AREA BY OPENING
    WINDOWS AND USING EXHAUST FANS.
Protective Gloves:NEOPRENE, NITRILE OR NATURAL RUB GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:CONTACT LENSES SHOULD NOT BE WORN WHEN
    HANDLING THIS MATERIAL.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WASTE DISP METH:VARY CONCERNING THE DISPOSAL OF THESE CHEMICALS CONSULT
    LOCAL, STATE AND FEDERAL AGENCIES FOR PROPER DISPOSAL METHOD IN
    YOUR AREA.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:165F,74C
Vapor Pres:25
Spec Gravity:1.06
Evaporation Rate &amp; Reference:1.0 (CCL4 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN, AMBER OIL WITH A DISTINCTIVE SOLVENT ODOR
Percent Volatiles by Volume:25

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO2 & SOX.

====================  Disposal Considerations  ====================

Waste Disposal Methods:PROD IS CONSUMED IN USE. WHEN DISPOSING OF SPENT
    CNTNRS, DO NOT CRUSH, PUNCTURE OR INCIN. IN MOST STATES, QTYS
    TOTALING LESS THAN 220 POUNDS OF HAZ MATLS PER MONTH CAN BE DISP OF
    IN CHEM LANDFILL W/ O UT BEING DECLARED HAZ WASTE. SINCE REGS(SUPP
    DATA

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.